QWP stainless steel sewage pump use, maintenance and care
Rodent Pest Control,Mouse Glue Board,Weed Control Mat Rubber,Rodent Controller Suzhou Surface Protective New Material Technology Co.,Ltd , https://www.surfaceprotective.com
October 14 04:07:52, 2023
QWP stainless steel sewage pump is a type of stainless steel sewage pump, stainless steel sewage pump if you usually do not pay attention to the use, maintenance and repair, it is easy to lead to a short life of stainless steel sewage pump. Therefore, in daily life should pay more attention to QWP stainless steel sewage pump use, maintenance and care. QWP stainless steel sewage pump use, maintenance and care 1, in order to ensure the normal use and life of the pump should be carried out on a regular basis inspection and maintenance. 2, stainless steel sewage pump cable at least once a year, if damaged please give replacement. 3. Inspect the motor insulation and fastening screws at least once a year. If the motor insulation drops, please look for someone to repair. If the fastening screws are loose, please re-fasten. 4, seal ring should be replaced: long-term use in the sewage medium, the gap between the impeller and the seal ring may increase, resulting in decreased pump flow and efficiency, switch off the gate, the pump hoisted, remove the bottom cover, take Under the seal ring, according to the actual size of the impeller mouth ring seal ring, the gap is generally about 0.5mm. 5, stainless steel sewage pump long-term need, it should be cleaned and placed in a ventilated and dry place, pay attention to antifreeze. If placed in water, run at least 30 min every 15 days (do not dry) to check its function and suitability. 6, the operation of the fault, please give the troubleshooting method is given, if still can not be resolved, and can not determine the cause, do not indiscriminately disorganized chaos, should immediately find someone to repair. 7, the factory has been injected into the amount of oil, used to lubricate the mechanical seal, the oil should be checked once a year. If you find water in the oil, it should be let go, replace the oil, replace the gasket, tighten the screw plug. After three weeks, it must be rechecked. If the oil becomes emulsion, the mechanical seal should be inspected and replaced if necessary. The above seven is a brief introduction to the use of QWP stainless steel sewage pump, maintenance and maintenance, through this article, hope you follow-up to be used in their daily lives, thereby enhancing the life of QWP stainless steel sewage pump. Further reading: IFAT China Guangzhou exhibition industry leaders building water pump manufacturers ranking article belongs to Internet industry (Xiamen) Co., Ltd. All are welcome to reprint, please indicate the source and author of: Asian pumps Network Editor: lindj (QQ / WeChat:) Starting: http://beng.liuti.cn/ (Service Hotline:)